Electric Golf Trolley Spares and Parts – HOME MENU

Golf Trolley not Charging the Battery

Plugging my battery charger in it has never shown a red charging light in it goes straight to the green charged light. The trolley will only go a few holes before it needs pushing. So it seems my golf trolley charger is not charging the battery.
Normally although there are a few circumstances other things can be at fault, but it is usually the connection between the battery and trolley or battery charger.  Therefore I would first check or replace the battery connection lead.
Could you tell me when charging my Pro rider is the light ment to be green
when charging thanks
When putting the battery on charge and it is taking a charge it should show a RED light. If not it could be the battery lead connection is poor in someway.
Hi Jim
Thanks for that. Am I correct in noticing the charger has a green light which turns red when connected to the battery that requires a charge.
As I said the battery connection is brand new and whilst I will double check its correct fitted I am at a loss to understand it further. Again the battery is relatively new but cannot rule out a fault with it.
Yes you are correct; the battery charger when all connections are working and the battery is needing charged e.g. below 14 volts, automatically starts off at a RED light – this means the charge is getting through to the battery. Once charged, it should go to green OR if there is a good connection and the charger gets a voltage signal of around 14 volts, it will then go to green light.

Caution the battery charger will also read Green if the connection is not good or disconnected in anyway. This can be proved by pulling out the mains plug i.e. switching off the mains socket, you will then notice the charger going to a green light.

It is advisable always to start with connections: Make sure your battery lead is in good condition and is making a good connection at both ends; the battery connectors and the round 3 pin socket is good. IF in any doubt always purchase a new golf trolley battery lead before purchasing any new battery. It is very rare for the charger to be at fault. The order of problems in order would be from most likely the fault first;

  1. Connections dirty or poor at the 3 pin battery lead.
  2. Damage to the round 3 pin battery connector.
  3. Damaged leads (pulled) at the battery terminals.
  4. Pulled damage leads at the round 3 pin battery connector.
  5. Poor connection at the battery terminals dirt or corrosion.
  6. Battery damaged by a fall or dropped.
  7. General battery fault.
  8. Charger fault.

3.  battery lead round 3 pin connector

3. Damage to the 3 pin round battery connector leads