Various Golf Trolley Problems…

  • ProRider speed knob problem

    I recently inherited a pro rider trolley. However when changing the speed knob from 2 to 3 the speed goes from below walking pace to faster than walking pace. Could you tell me if this can be adjusted or if you think there is a faulty part. Auto 10 20 30 m stop works as…

  • Trolley got knocked and lost all power

    QUESTION: I was wondering if you could help me.  Last week when I was out on the golf course as I was going over a bridge my trolley banged over a small kerb and I lost all power.  I tried unplugging the battery and plugging it back in but nothing happened, I thought it may…

  • Golf trolley right wheel is moving faster than the left

    The right hand wheel is faster than the left – do i need a new clutch on the left side? If yes do you have one and how much. PS: When turning the wheels by hand the right hand side is resisting the left free wheels. If your electric golf trolley is pulling to the…

  • Golf Trolley is not lighting up

    My golf trolley LED panel doesn’t light up. I think my battery is fully charged, Kindly advise what I should do. The S1G controllers are the correct for the ProRider golf trolley. We always recommend getting the LED circuit at the same time, this is because sometimes one faulty part can cause electrical failure in…

  • speed control switch or controller

    My trolley has developed an intermittent fault. Sometimes it works fine and then it will only go on very fast speed when the control knob is switched on and turned even if the knob is turned very slowly. Switched on and off again it sometimes works perfectly . Do you think I need a new…

  • Golf Trolley Battery Cable

    Golf Trolley Battery Cable

    What is a golf trolley battery cable Normally the power is transmitted from the battery to the electrics by means of a golf trolley battery cable.  This is made up of two wires; one red (positive) and one black (negative).  The two wires are wrapped in an insulated black plastic sheath.  This battery cable sheath…

  • Golf trolley controller

    Golf trolley controller

    Is there a fault with my golf trolley controller I think from your support page my golf trolley controller is at fault.  When I switch the trolley on and gradually turn the control knob through the pace numbers, it seems the wheels are going at the same pace from 1 to 9 , very fast,…

  • battery charger and connections

    Hi, my display has red light on only, no other lights on except the display. When I turn speed knob there’s a click but numbers pop up erratically on display then red light stats flashing. The battery is fairly new (18 months and not used very much over that period) and when I try to…

  • Do the parts fit the S1 Motocaddy golf trolley

    Will this controller fit my S1 2013 golf trolley, it looks similar. If you mean the Motocaddy S1 golf trolley then sorry at the moment we don’t sell spares for any of the Motocaddy golf trolleys. If this is for a different make please email or contact us page and give any details and we…

  • golf trolley wheel keeps coming off

    My right hand wheel keeps coming of intermittently once every 9 holes I’m sure the wheels are on the right side as I push the trolley the right hand wheel is on the same side as my right any thoughts I would check there is no dirt clogging up the mechanism or inside the grove…

  • ProRider golf trolley will not start

    ProRider golf trolley will not start

    Fault with ProRider golf trolley not moving The fault is that the ProRider golf trolley does not work at all.  It will not start up or move forward under power. All of the display lights work, the speed controller shows the speed variation. The 3 distance settings are illuminated depending which button is pressed, but…

  • Electric golf trolley will not start up

    I have a ProRider electric golf trolley and it developed a fault. I can’t get the trolley to go by using the knob. I can switch the trolley on and it lights up but as soon as I try to turn the speed knob nothing happens, the display stays at zero. All the lights are…

  • T handle golf trolley circuit board

    My wife has a Pro golf electric trolley that looks exactly like a Prorider trolley. It has a T-Bar handle with stop//start and distance control buttons but will not work at all. Can you please let me know if the printed circuit board is the same as the Prorider type which you sell Yes, this…

  • ProForce Golf Trolley Speed control erratic

    I have a ProForce and the one of the display panel buttons is broken and speed controller is erratic. The handle has also got a piece missing from it. If I was purchase the ProRider handle plus the display Panel and circuit board would I have any issues installing in place of the existing handle?…

  • golf trolley controller only goes to speed 4

    My golf trolley controller only goes to 4 would that be a problem with the board ? IF it has stopped going up any higher in speed then it most likely will be the speed control switch in the handle . (see photo) . This speed switch if it gets a knock or bumped i.e. when…

  • battery lead connected but no lights

    I’ve connected leads to battery fine then connected 3 pin connector to trolley fits perfectly but no lights come on ? Nothing old put old connector back on green light come on trolley. Changing connector as trolley keeps stopping every two minutes so thought it might be a faulty connector. If the trolley is completely…

  • controller clicks but motor not turning

    Battery checked and connected to trolley all 3 coloured lights come on when you turn speed switch a click is heard from controller but no movement Motor checked with spare battery and runs normal. Any advice please. Controller? Although the controller clicks it may not be working. Regards the handle circuit, I would think if…

  • golf trolley speed control switch reversed

    I bought a control switch from you and fitted it yesterday. I followed the colour coding between the switch and the circuit board. Unfortunately the switch now works in he reverse order – ie when moved clockwise it goes from speed 7 to 0. Can I reverse the outside two wires and will this cause…

  • Golf Trolley Axle Pin

    My trolley is a Waslin- golf trolley, the only one I can find that resembles it is the pro rider? It seems like the axle pin on one side of my trolley has snapped, it doesn’t seem like its a split pin but a solid piece of metal going through the axle. I have ordered…

  • Battery Lead Round Connector Fault

    I have replaced the battery with a light one. When switching the power on I have brief flashes on the screen. Help! If the golf trolley display is flashing constantly then this will most likely be the battery is too low on charge, but this sounds like a power connection problem. It won’t be the…

  • ProRider Golf Trolley Submerged into Water

    ProRider Golf Trolley Submerged into Water

    My wife’s ProRider electric golf trolley sank into a pond and now doesn’t work. I have stripped down and dried. It started to work but speed controller didn’t. The LCD lit but now doesn’t. The sealed silver box seemed dry but when I opened it was wet.  I have the same trolley so can switch…

  • ProRider golf trolley losing all power

    I have a pro rider trolley which is less than a year old but I cant find the receipt. The trolley loses all power, nothing on the display.12 volt DC power is present at the S1G controller PCB. I line checked the cable between S1G and display D-64186 which is OK. When it does power…

  • Ben Sayers Golf trolley speed fault

    Controller clicks when controller knob is turned, does not run until knob gets to No 5 but only very slow. Same on ABC dist control only runs slow. Checked all connections , tried with TWO fully charged batteries still same faults . Could you advise , checking your site it seems like faulty control box…

  • golf trolley display showing flashing red light

    When switched on the red light comes on and starts flashing, the speed controller does click when switched on. Have changed the handle controls but still have the same problem. The battery info. is standby use 13.5 – 13.8v the reading on the meter is 13.65v. The battery charger is only showing the green light…

  • Pro-Force golf trolley wheel retention

    Hi, I have a Pro Force electric trolley and the left wheel retention mechanism has failed. It has a sliding toggle that should be spring loaded but the spring appears to be broken and will no longer lock the wheel to the axle. The wheel retention clip you sell appears to be different to the…

  • Prorider golf trolley battery cable

    I’m looking for a bit of advice. I have a Ben Sayers (Pro Rider) golf trolley. The battery is supposed to be 36 holes, however after 1 year I am only getting 18 holes out of the battery. When I put the battery on to charge it goes red straight away and then shortly after…

  • Pro Rider golf trolley jumping but not moving forward smoothly

    Many thanks for your reply. I have checked things out and confirm; The speed control switch lights up but even when I turn it it stays on 0 and pulses occasionally it goes on to 1 but still pulses. There is a constant clicking sound which appears to be coming from the S1 controller. The…

  • ProRider golf trolley clutch testing

    With this Pro Rider golf trolley the drive shaft is working and responds to the speed control.I can see the drive shaft turning but the wheels do not respond and there is no forward motion.Your advice would be appreciated. I would first check your wheels are secured properly and that the axle pins are catching…

  • Replacing a difficult golf trolley clutch – screws stuck

    The right wheel I ordered from you in 2013 has a slipping clutch. I have tried to remove it without success. If you are having a problem in removing the clutch from the wheel, here is my recommendation for helping you remove a difficult wheel clutch. The original clutches from 5 years ago (2013) were…

  • ProRider golf trolley speed control not working

    My ProRider golf trolley has a problem with the speed jumping around. The speed control display jumps around stops and then goes to no 7. Does this mean I need a new speed controller, potentiometer or anything else. Please advise which to purchase Thanks your help I have found in previous experience when the Pro…

  • ProForce golf Cart Display Fault

    My father-in-law has a pro force golf cart which has developed a problem of showing no power on the display when turned on. the battery is new and fully charged, the code he has is D61846 for the pcb board, is this correct, do you sell replacement boards to match this code, and is it…

  • Golf Trolley not Charging the Battery

    Plugging my battery charger in it has never shown a red charging light in it goes straight to the green charged light. The trolley will only go a few holes before it needs pushing. So it seems my golf trolley charger is not charging the battery. Normally although there are a few circumstances where other…

  • Golf Trolley Cuts Out

    Hi, hope you can help, when I switch power on the led 0 flashes, when the speed controller is turned the main controller clicks as it should but the trolley does not go, the numbers flash and as you turn it up it cuts out, I have changed the speed controller and the battery seems…

  • Speed control jumping around

    You will see from the attached correspondence that we have chatted before re my trolley problems. I had the trolley repaired eventually and the problem was that one of the connection wires in the main cable had snapped in the connector socket that went into the controller panel. The guy soldered the wire back together…

  • Golf trolley not moving forward – wheels turn off the ground

    I have not used my trolley for 15 months and now it does not seem to have power as it will not go forward under load. If I lift the driving wheels off the ground and increase the speed, the wheels turn and go faster as the speed increases. However, when I place the driving…

  • Golf trolley stops and restarts again

    I have a Precision trolley with a T handle. All lights come on. Using the controller, after turning it up, it will go for a bit then stop and restart again, and repeat the sequence. It also happens if I set the speed then just use the on off button. It also starts on its…

  • Trolley lighting up before I press the on button

    When battery is fitted to cart all the control panel lights up before I’ve  pressed the on button , but nothing alters when I try to select a speed level trolley won’t move. With the golf trolley lighting up before any on button is pressed, this would suggest the control box or handle circuit has…

  • Motor turns wheels do not move on the ground

    My motor responds to the controls when the wheels are off the ground and there is no resistance. when the wheels are grounded a motor/drive gear can be heard spinning but the wheels are not spinning. Suspect the drive gear/ clutch to the underside that is attached to the axle, can this be purchased separately…

  • Electric Golf Trolley Spares

    We supply electric golf trolley spares to the public via our support and online sales shop.  You can find many spares for different trolleys.  Having a problem with your trolley, don’t worry, we have a support page which can help determine what is wrong and what spare is needed.  Then also is our support on…

  • Golf Trolley Not Moving

    I have fitted the new speed control switch. I press start switch and digital light appears at Zero. When I then operate the starter switch the digital numbers appear but start flashing with very minimal movement of trolley. Can you give me a reason for this please, Thank you in anticipation. On this type of…

  • Electric golf trolley speed control fault

    Hi, My Pro Rider golf trolley speed control has stopped working, can you help.  The trolley is switching on the power no faults and the display is showing as normal.  The fault lies when I try to turn the speed of the trolley up or down it won’t work.  The numbers are not moving.  Sometimes…

  • Should Golf Trolley Battery Leads be fused?

    Golf Trolley Battery Leads There are only a couple of types of golf trolley battery leads.  Most have two wires negative and positive.  The negative wire is normally covered with black insulation covering.  The positive wire is mainly a red cover of insulation.  The two wires are then sheathed together with a thin but strong…

  • Golf trolley not connecting to the wheels

    I have this trolley but now the motor works but is not connecting to the wheels. Can you please suggest what I can do to correct this. This sounds like all is working except the trolley is not got any power driving the wheels forward.  Best thing to do is check to see if the…

  • Pro Rider golf trolley speed all over place – stop and go

     My pro rider has not been used for 3 years as it became very unreliable. It would just stop and then go again, the speed reg. was all over the place and it was just unusable. Have now decided to have another go. In your opinion do you think the control box may be the…

  • Pro-force electric golf trolley only works on preset distances

    Hi, I have a 2014/15 model pro-force electric golf trolley. It works on the pre-set a,b,c fixed distances fine but doesn’t work on the Manual mode. The numbers still go up and down when the knob is turned but no movement. The screen seems fine, it’s had a new knob so does that mean it…

  • Wheel Clutch

    Wheel Clutch

    Golf Trolley Wheel Clutch CAUTION ALWAYS; replace both clutches at the same time to stop stress of imbalance from worn sides! Purchase HERE   What is a wheel clutch A golf trolley clutch is used in electric golf trolleys that have motors to drive them forward.  The motor in turn drives the shaft or axle…

  • Golf Trolley Battery Lead

    Golf Trolley Battery Lead

    BUYING  GOLF TROLLEY BATTERY LEAD   What is a Golf Trolley Battery Lead A battery cable consists of twin wires connected to the terminals of a battery which run to an adapter or plug. This plug connector is then used to connect only the correct round so as to allow the electric current to flow…

  • New Golf Trolley Design GTX36

    Precision GTX18 light in black frame The new quality design from Precision Golf Trolleys includes a new comfort handle and comfort fold points, it comes with a 18 hole light weight battery as standard, a 200watt motor, and many accessories available. This latest GTX top range version is great value for money.  Its built and…

  • Speed Control Switch

    Speed Control Switch

    What is a Golf Trolley Speed Control Switch The other name for the spare part is sometimes referred to as a potentiometer or pot original name being a rheostat. This component acts as a speed control switch for a golf trolley by way of increasing the speed of the motor through a control stepping up…

  • Is my golf trolley battery working

    I have had a Stowamatic golf trolley for a few years and it is getting to the end of the round the display starts to flash, sometimes the whole trolley’s power turns off.  I try to turn it on again and it does come on but turns off again.  Could this be the battery or…

  • Turning the speed dial is erratic and display is sticking and jumping

    My Pro Rider golf trolley speed number display is erratic and is jumping a few numbers at a time.  Sometimes when turning the speed control switch up or down it sticks at a certain speed then if I keep turning, it then jumps to 7 top speed  as if it is missing some speed settings in…

  • Connected the battery lead terminals the wrong way round

    Hi, Could you please help me with a problem I have created on my golf trolley.  I connected the battery the wrong way round . It blew the fuse which I replaced but everything is now dead. Clearly I have blown something more.? Is this liable to be the controller and could it have damaged…

  • Flashing speed indicator on my Precision golf trolley

    The speed indicator on my Precision GTX trolley, purchased in Aug 2013, started flashing during the tail end of my round today.  Although I upgraded from a 18 hole battery to a 36 hole battery three years back, I am assuming that this flashing behaviour indicates that the battery no longer has capacity to manage 18…

  • ProForce Electric golf trolley not starting up

    I have a 15 month old Pro-Force digital golf trolley. It has a button for 10 yards 20 yards or 30 yards free run. When I start it up all 3 lights come on as does the digital display. I turn the control knob and when it passes from 0 to 1 there is a…

  • Golf trolley just stops in a round and the power just switches off

    I have a PRO FORCE electric trolley purchased 3 years ago. I am experiencing a problem that cause the trolley to struggle on the course and occasionally power off. It starts back up again, but it runs for a while, then power cuts again. We have a hilly course, and it is a struggle. Initially,…

  • My golf trolley speed control switch isn’t working

     I found my display speed numbers are not going up to the maximum speed well not all the time, I find sometimes the trolley LED numbers stop around 5 and sometimes won’t go all the way up to speed 7 on the display.  Please can anyone let me know what they think is wrong ?…

Got any book recommendations?